亚洲国产精久久久久久久,久久精品视频免费观看,欧美亚洲另类色国产综合,国产精品国产三级国快看

　　全自動涼茬機的優勢以及使用前檢查步驟

The advantages of fully automatic stubble cooling machine and the pre use inspection steps

　　全自動涼茬機的優勢

The advantages of fully automatic stubble cooling machine

　　全自動涼茬機主要由機架、風機、傳送帶和依次連接于傳送帶上的攪籠、打料棍、翻料棍、下料裝置、出料管組成，所述的風機固定在傳送帶側端的機架上并少設置為三臺，所述的下料裝置由下料斗和固接于下料斗下部的下料輥組成，所述的機架上設有高于傳送帶輸送線兩邊的擋板。

The fully automatic stubble cooling machine mainly consists of a frame, a fan, a conveyor belt, and a stirring cage, a feeding rod, a flipping rod, a feeding device, and a discharge pipe sequentially connected to the conveyor belt. The fan is fixed on the frame at the side end of the conveyor belt and at least three are set. The feeding device is composed of a feeding hopper and a feeding roller fixed to the lower part of the feeding hopper. The frame is equipped with a baffle higher than both sides of the conveyor belt conveyor line.

　　使用時，酒茬在傳送帶上通過，在打碎和攪拌的同時風機工作，迅速降溫，冷卻后的酒茬在下料裝置中與酒曲自動混合均勻。本實用新型全自動涼茬機提高了冷卻效果、降低了功耗，了現有設備自積堵塞現象，并實現了酒茬和酒曲的自動混合。

When in use, the wine residue passes through the conveyor belt, and the fan works while crushing and stirring to quickly cool down. The cooled wine residue is automatically mixed evenly with the wine yeast in the feeding device. The fully automatic cooling stubble machine of this utility model improves the cooling effect, reduces power consumption, solves the problem of self accumulation blockage in existing equipment, and realizes the automatic mixing of wine stubble and wine yeast.

　　在啟動涼茬機之前，我們應當先檢查機器的電機是否正常，再去啟動設備。在檢查時，應同時使用吹風機對電機內的灰塵等污垢雜物清理干凈，還要測量接線是否合格，如果發現電機出現機械損傷或者火花灼痕應當立即進行必要的處理工作。

Before starting the cooling machine, we should first check whether the motor of the machine is normal before starting the equipment. During the inspection, a hair dryer should be used to clean the dust and other debris inside the motor, and the wiring should also be measured to ensure compliance. If mechanical damage or spark marks are found on the motor, necessary treatment work should be carried out immediately.

　　電機使用前的檢查方法

Inspection methods for motors before use

　　1、用壓縮空氣或手動吹風機吹凈電動機內部灰塵、電刷粉末等，污垢雜物。

1. Use compressed air or a manual hair dryer to blow away dust, brush powder, and other debris inside the motor, and remove dirt and debris.

　　2、拆除與電動機連接的一切接線，用絕緣電阻表測量繞組對機座的絕緣電阻。若小于0．5MΩ時，應進行烘干處理，測量合格后再將拆除的接線恢復。

2. Remove all wiring connected to the motor and measure the insulation resistance of the winding to the base using an insulation resistance meter. If it is less than 0.5M Ω, it should be dried and the removed wiring should be restored after passing the measurement.

　　3、檢查涼茬機換向器的表面是否光潔，如發現有機械損傷或火花灼痕應進行必要的處理。

3. Check if the surface of the cooler's commutator is smooth. If mechanical damage or spark marks are found, necessary treatment should be taken.

　　4、檢查電刷是否嚴重損壞，刷架的壓力是否適當，刷架的位置是否位于標記的位置。

4. Check if the electric brush is severely damaged, if the pressure on the brush holder is appropriate, and if the position of the brush holder is at the marked position.

　　5、根據涼茬機電動機銘牌檢查直流電動機各繞組之間的接線方式是否正確，電動機額定電壓與電源電壓是否相符，電動機的起動設備是否符合要求，是否完好無損。

5. According to the nameplate of the cooling machine motor, check whether the wiring between the windings of the DC motor is correct, whether the rated voltage of the motor matches the power supply voltage, whether the starting equipment of the motor meets the requirements, and whether it is intact and undamaged.

　　全自動涼茬機是能酒茬攤涼攪拌后，加入酒曲混合的設備。工作時間短、非常節約資源、自動加曲卸料、減輕了工人們的勞動強度，還杜絕了浪費糧食的現象。與糧食接觸的部分均為的不銹鋼材料。此外，該機在使用時輸送、攪拌、下曲是均可變頻調速的。

The fully automatic stubble cooling machine is a device that can cool and stir the wine stubble, and then add the wine yeast for mixing. Short working hours, very resource efficient, automatic addition and unloading of materials, reducing the labor intensity of workers, and also eliminating the phenomenon of food waste. The parts in contact with grain are all made of high-quality stainless steel materials. In addition, the machine can be used with variable frequency speed regulation for conveying, stirring, and downward bending.

本文由全自動涼茬機提供技術支持，更多的詳細精彩內容請點擊我們的網站http://m.sdlngcjx.com我們將會(huì )全心全意為您提供滿意的服務。

This article is supported by a fully automatic stubble cooling machine barrel. For more detailed and exciting content, please click on our website http://m.sdlngcjx.com We will wholeheartedly provide you with satisfactory service.