小型釀酒設備有很各種類型。在一切正常狀況下,釀酒廠應用大中型機器設備開展來釀制純糧酒的,而像夜店,飯店和酒店餐廳應用的中小型機器設備就可以考慮制酒的要求了。中小型機器設備事實上應用起來相對性簡易,在一切正常狀況下,生產廠家將出示初期運用具體指導,假如使用人里有釀酒師，那么就比較好了,應用小型釀酒設備制酒時,對制酒的技術標準也很高。
There are many types of small wine making equipment. Under all normal conditions, breweries use large and medium-sized machinery and equipment to brew pure grain wine, while small and medium-sized machinery and equipment used in nightclubs, hotels and restaurants can consider the requirements of liquor making. In fact, small and medium-sized machinery and equipment are relatively simple to use. Under all normal conditions, the manufacturer will show specific guidance on the initial application. If there are winemakers among the users, it will be better. When using small-scale brewing equipment to make wine, the technical standard for liquor making is also very high.
酒的需求是很大的,但因為勞動者耗費很大,效率很慢,實際效果并不是非常好。小型釀酒設備的出現不用消耗很多的人力資源,也不用消耗很多的時間,帶來了很多的便利。
The demand for wine is great, but the actual effect is not very good because of the high labor consumption and slow efficiency. The emergence of small wine making equipment does not need to consume a lot of human resources and time, which brings a lot of convenience.
在購小型釀酒設備后必須按照技術人員教授的方法和說明書中的圖紙進行安裝。合理布置鍋爐、蒸料桶等設備位置。使用前用蒸汽進行多方面的清理工作。
After the purchase of small wine making equipment, it must be installed according to the method taught by technical personnel and the drawings in the manual. Reasonable layout of boiler, steam drum and other equipment location. Use steam to clean up before use.
在進行前我們應該檢查蒸汽導管的連接是否正常,需要開啟的閥門是否已經打開,以及蒸汽桶的蓋子是否已經打開。然后打開加水閥,將水加到高水位線,然后開始燒水。水煮沸大約半小時后,關火,蒸汽清理工作就完成了。這期間鍋爐在燃燒時,必須打開鍋爐上方的蒸汽閥。
Before proceeding, we should check whether the connection of steam pipe is normal, whether the valve to be opened has been opened, and whether the cover of steam drum has been opened. Then open the water valve, add the water to the high water mark, and then start to boil water. After the water boils for about half an hour, turn off the fire and the steam cleaning is finished. During this period, when the boiler is burning, the steam valve above the boiler must be opened.
小型釀酒設備的蒸汽柜要避兔無水空燒,有時因為粗心,蒸汽柜內的水已經被燒掉,此時不會(huì )再有水分導致出現空燒,這不僅會(huì )造成設備的巨大損失,還可能引起火災。因此,每個人都必須注意這一點應養成良好的習慣,在每次蒸酒完后,必須進行排水工作,并及時清洗設備,不然內部的物料殘渣會(huì )導致管路出現堵塞導致在日后的使用中造成影響。
The steam cabinet of small wine making equipment should avoid empty burning without water. Sometimes, the water in the steam cabinet has been burned out because of carelessness. At this time, there will be no water to cause empty burning. This will not only cause huge loss of equipment, but also cause fire. Therefore, everyone must pay attention to this point and form a good habit. After each steaming, drainage must be carried out and the equipment should be cleaned in time. Otherwise, the internal material residue will cause blockage of the pipeline, which will affect the use in the future.
不銹鋼酒罐的產品概述及特點 2024-06-13 
